|
Rotary Tech - General Rotary Engine related tech section.. Tech section for general Rotary Engine... This includes, building 12As, 13Bs, 20Bs, Renesis, etc... |
|
Thread Tools | Display Modes |
![]() |
#1 |
The quest for more torque
Join Date: Sep 2008
Location: Sheboygan, Wisconsin
Posts: 855
Rep Power: 17 ![]() |
Causes of Rotary engine failure
I would make this a poll, but I would be sure to miss some common failure mode, so I will not do so.
Here is what I have found: Gradual Loss of compression: Caused by: Chrome Flaking (Primarily effecting 12As, pre-'86 13Bs) - Also seen some on S4s. Corner seal chipping -housing wears to allow corner seal to overextend, it get crooked and ruins side plate (Typically seen on S4 NAs, although I just found an S5 with the initial stages of it). Oil Seal Failure: Caused By: Dirty oil Overrevving when cold Age Naturally aspirated: S4 engines lose coolant seals: Caused by: Improper antifreeze Housing corrosion (improper antifreeze or old age) Age of seals (brittle) Overheating housing material composition/porosity issues S5 engines lose coolant seals: Caused by: Overheating Age of seals (brittle) (I have not seen the other failure modes for an S5) Engine seizes: Caused by: Running out of oil (I have never seen this one, but it must exist) Oil pickup tube coming off Sitting too long and having carbon buildup jam an apex seal, preventing the engine from rotating Carbon buildup in intake ports (especially the 6PI of the front rotor) coming loose and jamming in the combustion chamber as the rotor passes TDC Massive apex seal failure OMP failure and no premix (never seen, but must exist) Fasteners dropped down the intake Apex Seal Failure: Caused by: Excessive wear (especially on the pre-'86 13Bs and 12As @ > 200,000 miles) Carbon buildup breaking loose as a chunk and going through the engine Carbon buildup on spark plug catches apex seal and nicks the center, starting a scoring pattern on the housing Fasteners dropped down the intake Excessive Nitrous Oxide use Turbo (this is where my experience is much more limited): S4 coolant seal failure: (same as NA) S5 coolant seal failure: (same as NA) Engine seizes: Running out of oil Oil pickup tube falling off Apex seal failure: Most common cause is stock ECU cutting fuel to rear rotor during an overboost condition. Frequently caused by exhaust upgrades or lack of exhaust maintenance. Detonation under boost (Carbon buildup decreases detonation resistance over time) Lean detonation due to fuel starvation (plugged filter or empty tank) Pre-ignition caused by improper tuning/ECU spark timing errors. Side seal failure: Improper Porting techniques/Improper Port size Severe overheating Carbon Buildup Turbo failure: Oil Seals (fills intercooler with oil sludge, smokes really bad, can kill engine with carbon lock) Bearings (usually on a modified car (FCD, etc.)) Exhaust turbine (Never seen, but must exist) compressor wheel: Corrosion/pitting fasteners going through the turbo Nut coming loose (only heard of once, on rebuilt turbo) The purpose of this thread is to build a list of common failures to help those who have not yet had them to avoid them. If you have maintenance procedures that avoid these failures, please include them too. Thanks for the excellent input so far! Please continue to contribute, I think this would be a service to the rotary community. This list may become a mess, suggestions for better sorting are also welcome (Generation Specific / Failure with generation description / etc.).
__________________
1986 GXL ('87 4-port NA - Haltech E8, LS2 Coils. Defined Autoworks Headers, Dual 2.5" Exhaust (Dual Superflow, dBX mufflers) 1991 Coupe (KYB AGX Shocks, Eibach lowering springs, RB exhaust, Stock and Automatic) Last edited by NoDOHC; 09-29-2009 at 08:42 PM. Reason: Update |
![]() |
![]() |
Bookmarks |
Thread Tools | |
Display Modes | |
|
|